page 1 of 2 www.aecsensors.com sales department tel: (888) 847-6552 dg29 miniature automotive pcb power relay contacts contact number & arrangement spdt (1 form c), 2 x spdt contact material agsnoino max. switching voltage dc 40v min. switching current / voltage 100ma / 12vdc rated load 20a at 14vdc max. continuous current 25a max. switching current make 25a break 25a initial resistance <100m?, max. at 0.1a/6vdc coil rated voltage dc 12v, 24v must release voltage 0.1un operating range of supply voltage see coil table 1 rated power consumption dc 560mw - see coil table 1 insulation insulation resistance 100m? at 500vdc, 50%rh dielectric strength coil to contact 550vrms, 1min contact to contact 550vrms, 1min general data operating time (typical) ms 4 release time (typical) ms 2 electrical life ops 2 x 10 5 mechanical life ops 1 x 10 7 dimensions l x w x h 17.5 x 9.2 x 13.5 mm (single), 17.5 x 16.9 x 13.5 mm (twin) weight 4g / 8g approx. ambient temperature storage -40 to 155c operating -40 to 85c shock resistance functional: 300m/s 2 ; destructive: 450m/s 2 vibration resistance 60m/s 2 , 10hz-500hz ? miniature - only 14 x 7.2 x 13.5mm ? optimised for dc switching ? slim spdt and twin 2 x spdt ? two separate relays in miniature ? rohs compliant ref: dg29 080411jhm
pcb mounting dimensions and wiring fig. 2 ordering codes type contact material contact arrangement cover protection and mounting coil code d g 2 9 - 7 0 - 5 - contact material 70 - agsnoino see table 1 contact arrangement 11 - spdt (1 c/o, 1 form c) 22 - 2 x spdt ( 2 x 1c/o, 2 x 1 form c) cover protection category 2 - in cover, fux tight - ip40 3 - in cover, sealed - ip67 connection mode 5 - for pcb dg29 miniature automotive pcb power relay ref: dg28 080411jhm coil data table 1 coil voltage code nominal voltage (vdc) coil resistance (?) 10% must operate voltage max. (v dc) must release voltage min. (v dc) 1012 12 254 7.2 1.0 1024 24 1020 14.4 2.0 page 2 of 2 www.aecsensors.com sales department tel: (888) 847-6552 overall dimensions fig. 1 wiring diagrams (bottom view) mounting holes (bottom view) all dimensions in mm specifcations are subject to change without notice. e&oe. notes: 1: all parameters, unless otherwise specifed, are measured at ambient temperature of 23 o c. 2: maximum make current refers to inrush current of motor load. 3: electrical life is strongly dependent of switching frequency, on/off ratio and environmental conditions.
|
